Diesel Generator Exhaust Noise
The most effective way to control exhaust noise is to install a muffler. But the noise reduction effect is not well. The main reasons are the unreasonable structure and the problematic processing technology. The technology problem can be improved by improving the process. The design idea of the muffler, mainly based on experience, and some design calculations are under ideal […]
Precautions for correct water discharge of geneset
1. The radiator cover should be opened when discharging water. If not opened, though part of the cooling water can flow out, as the amount of water in the radiator decreases, a certain degree of vacuum will be generated due to the closed radiator. And then will slow down or stop the water flow. It will freeze […]
Avoid radiator corrosion
Diesel generators will generate a lot of heat during operation. If the heat cannot be dissipated, it will cause damage to the engine, please keep good heat dissipation.In order to ensure that the diesel generator has a good heat dissipation effect, should do the following.
Solution For Radiator Water Spraying
When starting the engine or increasing the throttle to increase the engine speed, coolant is spraying from the radiator filling port. The main reason is that there are large blisters or cracks in the cylinder gasket or cylinder liner and head. This is because the pressure of the compressed air or gas in the cylinder […]
Diesel Generator Weak Operation
Diesel generators run weakly and emit heavy smoke. This is mainly due to insufficient fuel injection atomization and incorrect refueling time.
Prevention Of Generator High Temperature
High water temperature of diesel engine will usually cause boiling coolant in the radiator , the power decreases, the viscosity of the lubricating oil decreases, the friction increases, and even cause the diesel engine to pull the cylinder and cylinder head gasket burned. Below are main reasons for the high temperature of the diesel engine and preventions and improvements. 1 – […]
Reasons and solution of generator
The generator is difficult to start. There are dozens of reasons for generator start failure. The following will introducethe reasons that cause the generator to be unable to start or difficult to start. White smoke from the exhaust pipe when starting Black smoke rises from the exhaust pipe when startup When the fuel and air mixture burns […]
Water Enters The Diesel Generator
Due to structural constraints, diesel generators can’t be completely waterproof. When the rainy season season comes, generators may be affected by natural disasters such as floods and rainstorms. When water enters the generator, you should take necessary measures to disconnect the external power supply and the battery connection line, prohibit running the engine, and check the water […]
Watertemperature sensor function of genset
1. Modify the fuel injection amount; increase the fuel injection at low temperature; 2. Correct the ignition advance Angle; increase the ignition advance Angle at low temperature, and delay the ignition advance Angle at high temperature to prevent deflagration; 3. Impact on the idle control valve; when the temperature is low, the electronic control unit […]
Poor Radiator Dissipation Performance
The radiator is the heat dissipating device of the cooling system, and sufficient heat dissipation area against the wind should be ensured.After the engine has been running for a period of time, the outside of the radiator will be covered by dust,and the inside will be blocked by dirt and impurities in the cooling system,causing […]
